Get Maintenance -> Scheduled maintenance service Guide for Kia Sportage SUV 2020

Maintenance

SCHEDULED MAINTENANCE SERVICE

Follow the Normal Maintenance Schedule if the vehicle is usually operated where none of the following conditions apply.

If any of the following conditions apply, follow the Maintenance Under Severe Usage Conditions.

• Repeated driving short distance of less than 8 km (5 miles) in normal temperature or less than 16 km (10 miles) in

freezing temperature

• Extensive engine idling or low speed driving for long distances

• Driving on rough, dusty, muddy, unpaved, graveled or salt-spread roads

• Driving in areas using salt or other corrosive materials or in very cold weather

• Driving in heavy dust conditions

• Driving in heavy traffic areas

• Driving on uphill, downhill, or mountain roads repeatedly

• Towing a trailer or using a camper, or roof rack

• Driving as a patrol car, taxi, other commercial use of vehicle towing

• Driving over 170 km/h (106 mile/h)

• Frequently driving in stop-and-go condition

If your vehicle is operated under the above conditions, you should inspect, replace or refill more frequently than the

following Normal Maintenance Schedule. After 120 months or 150,000 miles continue to follow the prescribed main-

tenance intervals.

7 9

Maintenance

Normal Maintenance Schedule - Turbo Models

The following maintenance services must be performed to ensure good emission control and performance.

Keep receipts for all vehicle emission services to protect your warranty. Where both mileage and time are shown, the

frequency of service is determined by whichever occurs first.

MAINTENANCE

INTERVALS

Number of months or driving distance, whichever comes first

Months

12 24 36 48 60 72 84 96 108 120 132 144 156 168 180

Miles×1,000

Km×1,000

6

12 18 24 30 36 42 48 54 60 66 72 78 84 90

MAINTENANCE

ITEM

10 20 30 40 50 60 70 80 90 100 110 120 130 140 150

At first, inspect at 100,000 km (60,000 miles) or 72 months,

after that, inspect every 20,000 km (12,000 miles) or 24 months

Drive belts *¹

Engine oil and engine oil

filter

Theta II 2.0L T-GDI

R

-

R

I

R

I

R

-

Fuel additives *²

Air cleaner filter

Spark plugs

Add every 10,000 km (6,000 miles) or 12 months

-

R

-

I

-

R

-

I

-

R

-

Theta II 2.0L T-GDI

Replace every 72,000 km (45,000 miles) or 36 months

Inspect every 100,000 km (60,000 miles) or 72 months

Valve clearance *³

I : Inspect and if necessary, adjust, correct, clean or replace.

R : Replace or change.

*¹: The drive belt should be replaced when cracks occur or tension is reduced.

*²: If TOP TIER Detergent Gasoline is not available, one bottle of additive is recommended. Additives are available from your

authorized Kia dealer along with information on how to use them. Do not mix other additives.

*³: Inspect for excessive valve noise and/or engine vibration and adjust if necessary. Have an authorized Kia dealer perform the

operation.

7 10

Maintenance

Normal Maintenance Schedule - Turbo Models (CONT.)

MAINTENANCE

INTERVALS

Number of months or driving distance, whichever comes first

12 24 36 48 60 72 84 96 108 120 132 144 156 168 180

12 18 24 30 36 42 48 54 60 66 72 78 84 90

10 20 30 40 50 60 70 80 90 100 110 120 130 140 150

Months

Miles×1,000

Km×1,000

6

MAINTENANCE

ITEM

Climate control air filter

Vacuum hose

R

I

R

I

R

I

R

I

R

I

R

I

R

I

R

I

R

I

R

I

R

I

R

I

R

I

R

I

R

I

At first, replace at 200,000 km (120,000 miles) or 10 years :

after that, replace every 50,000 km (30,000 miles) or 24 months

Coolant (Engine)

Battery condition

I

Brake lines, hoses and connections

(Including booster)

Disc brakes and pads

I

Steering gear rack, linkage and boots

Driveshaft and boots

Suspension mounting bolts

Air conditioner refrigerant

Air conditioner compressor

Propeller shaft

Exhaust pipe and muffler

I : Inspect and if necessary, adjust, correct, clean or replace.

R : Replace or change.

7 11

Maintenance

Normal Maintenance Schedule - Turbo Models (CONT.)

MAINTENANCE

INTERVALS

Number of months or driving distance, whichever comes first

Months

12 24 36 48 60 72 84 96 108 120 132 144 156 168 180

Miles×1,000

Km×1,000

6

12 18 24 30 36 42 48 54 60 66 72 78 84 90

MAINTENANCE

ITEM

10 20 30 40 50 60 70 80 90 100 110 120 130 140 150

Intercooler, in/out hose,

air intake hose

Theta II 2.0L T-GDI

I

Cooling system

-

Automatic transmission fluid

Rear differential oil (AWD) *⁵

Transfer case oil (AWD) *⁵

No check, No service required

-

I

-

I

-

I

-

Vapor hose, fuel filler cap, canister and fuel

tank

-

I

-

I

-

I

-

I

-

I

-

I

-

I

-

Fuel tank air filter *⁴

I : Inspect and if necessary, adjust, correct, clean or replace.

R : Replace or change.

*⁴: Fuel tank air filter are considered to be maintenance free but periodic inspection is recommended for this maintenance sched-

ule depends on fuel quality.

*⁵: Rear differential oil and transfer case oil should be changed anytime they have been submerged in water.

7 12

Maintenance

Normal Maintenance Schedule - Turbo Models (CONT.)

Number of months or driving distance, whichever comes first

MAINTENANCE

INTERVALS

Months

12 24 36 48 60 72 84 96 108 120 132 144 156 168 180

Miles×1,000

Km×1,000

6

12 18 24 30 36 42 48 54 60 66 72 78 84 90

MAINTENANCE

ITEM

10 20 30 40 50 60 70 80 90 100 110 120 130 140 150

Fuel lines, hoses and connections of each

part

-

I

-

I

-

I

-

Parking brake

-

I

-

I

-

I

-

I

-

I

-

I

-

I

-

Brake fluid

Cooling system hoses and connections

Clutch (if equipped) and brake pedal free play

All latch, hinges and locks

Inspect every 12,000 km (7,500 miles) or 6 months

Inspect every 24,000 km (15,000 miles) or 12 months

I : Inspect and if necessary, adjust, correct, clean or replace.

R : Replace or change.

7 13

Maintenance

Maintenance Under Severe Usage Conditions - Turbo Models

The following items must be serviced more frequently on cars normally used under severe driving conditions. Refer

to the chart below for the appropriate maintenance intervals.

R : Replace

I : Inspect and, after inspection, clean, adjust, repair or replace if necessary

MAINTENANCE

OPERATION

DRIVING

CONDITION

MAINTENANCE ITEM

MAINTENANCE INTERVALS

Every 5,000 km (3,000 miles) or 6

months

A, B, C, D, E,

F, G, H, I, J, K

Engine oil and engine oil filter Theta II 2.0L T-GDI

R

Air cleaner filter

I

R

I

More frequently

C, E

Spark plugs

A, B, F, G, H, I, K

A, C, E, F,

G, H, I, J

Automatic transmission fluid

Front brake disc/pads, calipers

Rear brake disc/pads

Parking brake

Every 100,000 km (60,000 miles)

More frequently

C, D, E, G, H

C, D, G, H

I

More frequently

I

More frequently

Steering gear box, linkage & boots/

Lower arm ball joint, upper arm ball joint

I

More frequently

C, D, E, F, G

7 14

Maintenance

MAINTENANCE

OPERATION

DRIVING

CONDITION

MAINTENANCE ITEM

Drive shafts and boots

MAINTENANCE INTERVALS

More frequently

I

C, D, E, F, G, H, I, J

C, E, G, H, I, J

C, E, G

Rear differential oil (AWD)

Transfer case oil (AWD)

Every 120,000 km (72,000 miles)

More frequently

R

I

Climate control air filter

(for evaporator and blower unit)

Propeller shaft

More frequently

C, E

Severe driving conditions

E-Driving in heavy dust conditions

F -Driving in heavy traffic areas

A-Repeatedly driving short distance of less than 8 km (5 miles)

in normal temperature or less than 16 km (10 miles) in freez-

ing temperature

G-Driving on uphill, downhill, or mountain road repeatedly

H-Towing a Trailer, or using a camper, or roof rack

B-Extensive engine idling or low speed driving for long dis-

tances

I -Driving as a patrol car, taxi, other commercial use or vehicle

towing

C-Driving on rough, dusty, muddy, unpaved, graveled or salt-

spread roads

J -Driving over 170 km/h (106 mph)

D-Driving in areas using salt or other corrosive materials or in

very cold weather

K-Frequently driving in stop-and-go conditions

7 15

Maintenance

Normal Maintenance Schedule - Non Turbo Models

The following maintenance services must be performed to ensure good emission control and performance.

Keep receipts for all vehicle emission services to protect your warranty. Where both mileage and time are shown, the

frequency of service is determined by whichever occurs first.

MAINTENANCE

INTERVALS

Number of months or driving distance, whichever comes first

Months

12 24 36 48 60 72 84 96 108 120 132 144 156 168 180

Miles×1,000

Km×1,000

7.5 15 22.5 30 37.5 45 52.5 60 67.5 75 82.5 90 97.5 105 112.5

12 24 36 48 60 72 84 96 108 120 132 144 156 168 180

MAINTENANCE

ITEM

At first, inspect at 96,000 km (60,000 miles) or 72 months,

after that, inspect every 24,000 km (15,000 miles) or 24 months

Drive belts *¹

Engine oil and engine oil

filter

Theta II 2.4L GDI

R

I

R

I

R

I

R

I

Fuel additives *²

Air cleaner filter

Spark plugs

Add every 12,000 km (7,500 miles) or 12 months

I

R

I

R

I

R

I

Theta II 2.4L GDI

Replace every 168,000 km (105,500 miles) or 84 months

Inspect every 96,000 km (60,000 miles) or 72 months

Valve clearance *³

I : Inspect and if necessary, adjust, correct, clean or replace.

R : Replace or change.

*¹: The drive belt should be replaced when cracks occur or tension is reduced.

*²: If TOP TIER Detergent Gasoline is not available, one bottle of additive is recommended. Additives are available from your

authorized Kia dealer along with information on how to use them. Do not mix other additives.

*³: Inspect for excessive valve noise and/or engine vibration and adjust if necessary. Have an authorized Kia dealer perform the

operation.

7 16

Maintenance

Normal Maintenance Schedule - Non Turbo Models(CONT.)

MAINTENANCE

INTERVALS

Number of months or driving distance, whichever comes first

Months 12 24 36 48 60 72 84 96 108 120 132 144 156 168 180

Miles×1,000 7.5 15 22.5 30 37.5 45 52.5 60 67.5 75 82.5 90 97.5 105 112.5

Km×1,000 12 24 36 48 60 72 84 96 108 120 132 144 156 168 180

MAINTENANCE

ITEM

Climate control air filter

R

I

R

I

R

I

R

I

R

I

R

I

R

I

R

I

R

I

R

I

R

I

R

I

R

I

R

I

R

I

Vacuum hose

At first, replace at 192,000 km (120,000 miles) or 10 years,

after that, replace every 48,000 km (30,000 miles) or 24 months

Coolant (Engine)

Battery condition

I

Brake lines, hoses and connections

(Including booster)

Brake discs and pads

I

Steering gear rack, linkage and boots

Driveshaft and boots

Suspension ball joints

Air conditioner compressor/refrigerant

Propeller shaft (AWD)

Exhaust system

I : Inspect and if necessary, adjust, correct, clean or replace.

R : Replace or change.

7 17

Maintenance

Normal Maintenance Schedule - Non Turbo Models (CONT.)

MAINTENANCE

INTERVALS

Number of months or driving distance, whichever comes first

Months

12 24 36 48 60 72 84 96 108 120 132 144 156 168 180

Miles×1,000

Km×1,000

7.5 15 22.5 30 37.5 45 52.5 60 67.5 75 82.5 90 97.5 105 112.5

12 24 36 48 60 72 84 96 108 120 132 144 156 168 180

MAINTENANCE

ITEM

Cooling system

-

I

-

I

-

I

-

I

-

I

-

I

-

Automatic transmission fluid

Rear differential oil (AWD) *⁵

Transfer case oil (AWD) *⁵

Vapor hose, canisrer and fuel filler cap

Fuel tank air filter *⁴

No check, No service required

-

I

-

I

-

I

-

Fuel lines, hoses and connections of each

part

-

I

-

I

-

I

-

Parking brake

Brake fluid

-

I

-

I

-

I

-

I

-

I

-

I

-

I

-

I : Inspect and if necessary, adjust, correct, clean or replace.

R : Replace or change.

*⁴: Fuel tank air filter are considered to be maintenance free but periodic inspection is recommended for this maintenance sched-

ule depends on fuel quality.

*⁵: Rear differential oil and transfer case oil should be changed anytime they have been submerged in water.

7 18

Maintenance

Maintenance Under Severe Usage Conditions - Non Turbo Models

The following items must be serviced more frequently on cars normally used under severe driving conditions. Refer

to the chart below for the appropriate maintenance intervals.

R : Replace

I : Inspect and, after inspection, clean, adjust, repair or replace if necessary

MAINTENANCE

OPERATION

DRIVING

CONDITION

MAINTENANCE ITEM

MAINTENANCE INTERVALS

Every 6,000 km (3,750 miles) or 6

months

A, B, C, D, E,

F, G, H, I, J, K

Engine oil and engine oil filter Theta II 2.4L GDI

R

Air cleaner filter

R

I

More frequently

C, E

Spark plugs

A, B, F, G, H, I, K

A, C, E, F,

G, H, I, J

Automatic transmission fluid

Brake discs and pads, calipers and rotors

Parking brake (Foot Type)

Steering gear rack, linkage and boots

Suspension ball joints

Every 96,000 km (60,000 miles)

More frequently

C, D, E, G, H

C, D, G, H

I

More frequently

I

More frequently

C, D, E, F, G

I

More frequently

7 19

Maintenance

MAINTENANCE

OPERATION

DRIVING

CONDITION

MAINTENANCE ITEM

MAINTENANCE INTERVALS

More frequently

C, D, E, F,

G, H, I, J

Drive shafts and boots

Rear differential oil (AWD)

Transfer case oil (AWD)

Climate control air filter

Propeller shaft

I

Every 120,000 km (75,000 miles)

More frequently

C, E, G, H, I, J

C, E, G

R

I

C, D, E, F,

G, H, I, J

More frequently

Severe driving conditions

E-Driving in heavy dust condition

F -Driving in heavy traffic area

A-Repeatedly driving short distance of less than 8 km (5 miles)

in normal temperature or less than 16 km (10 miles) in freez-

ing temperature

G-Driving on uphill, downhill, or mountain road repeatedly

H-Towing a Trailer, or using a camper, or roof rack

B-Extensive engine idling or low speed driving for long dis-

tances

I -Driving as a patrol car, taxi, other commercial use or vehicle

towing

C-Driving on rough, dusty, muddy, unpaved, graveled or salt-

spread roads

J -Driving over 170 km/h (106 mph)

D-Driving in areas using salt or other corrosive materials or in

very cold weather

K-Frequently driving in stop-and-go conditions

7 20

Maintenance -> Scheduled maintenance service for Your Kia Sportage SUV 2020

Popular Manuals